Руководство Fitting locations VW Polo 6 (AW1, AE1) 2018 - 2022

Fitting locations Volkswagen Polo 6 (model AW1) 2018 - 2021
Fitting locations Volkswagen Polo 6 restyling (model AE1) 2022 -
Расположение компонентов Фольксваген Поло 6

Contents:
Front, view VW Polo 6 from front
Front, view from front left / right
1.0l petrol engine, CHYB, CHYC
1.0l petrol/natural gas engine, CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF, DXTA
1.0l petrol engine, DFNA, DFNB, DSGB, DSGD
1.0l petrol engine, DLAA, DLAC
1.5l petrol engine, DADA, DPCA
1.6l petrol engine, CWVB
1.6l diesel engine, DGTC, DGTD
2.0l petrol engine, CZPC, DKZC, DNND
Dual clutch gearbox, 0CW
Dual clutch gearbox, 0D9
Dual clutch gearbox, 0GC
Manual gearbox
Front left of interior
Left footwell
Front right of interior
Dash panel
Steering wheel / Steering column
Front centre console
Left front seat
Right front seat
Rear interior
Roof
Doors
Heater and air conditioning unit / Climatronic
Connector assignments
Rear lid
Rear bumper
Rear side, view from left / centre view / view from right
Front of underbody / Rear underbody

Front, view from front, VW Polo 6 sales type AW1
Note: For models with sales type AW1



A - 4-pin connector -T4bf-, black/4-pin connector -T4o-, black
For models with pedestrian protection system
For models with no parking aid
A - 8-pin connector -T8i- , black/8-pin connector -T8a-, black
For models with no pedestrian protection system
For models with parking aid (PDC)
A - 14-pin connector -T14w- , black/14-pin connector -T14j-, black
For models with pedestrian protection system
For models with parking aid (PDC)
1 - Front right parking aid sender -G252-
For models with parking aid (PDC)
2 - Front right headlight -MX2-
3 - Front right sender for park assist steering on right side of vehicle -G569-
For models with park assist steering
4 - Adaptive cruise control unit -J428-
5 - Centre crash sensor for pedestrian protection -G693-
For models with pedestrian protection system
6 - Front left headlight -MX1-
7 - Front left sender for park assist steering on left side of vehicle -G568-
For models with park assist steering
8 - Front left parking aid sender -G255-
For models with parking aid (PDC)
9 - Left fog light bulb -L22-
9 - Left daytime running light bulb -L174-
10 - Treble horn -H2-
11 - Front passenger side crash sensor for pedestrian protection -G571-
For models with pedestrian protection system
12 - Front centre right parking aid sender -G253-
For models with parking aid (PDC)
13 - Ambient temperature sensor -G17-
14 - Front pressure hose sensor for pedestrian protection -G579-
For models with pedestrian protection system
15 - Front centre left parking aid sender -G254-
For models with parking aid (PDC)
16 - Bass horn -H7-
17 - Driver side crash sensor for pedestrian protection -G570-
For models with pedestrian protection system
18 - Right fog light bulb -L23-
18 - Right daytime running light bulb -L175-


Front, view from front, VW Polo 6 sales type AE1
Note: For models with sales type AE1



A - 4-pin connector -T4bf-, black/4-pin connector -T4o-, black
For models with pedestrian protection system
For models with no parking aid
A - 8-pin connector -T8i- , black/8-pin connector -T8a-, black
For models with no pedestrian protection system
For models with parking aid (PDC)
A - 14-pin connector -T14w- , black/14-pin connector -T14j-, black
For models with pedestrian protection system
For models with parking aid (PDC)
1 - Front right parking aid sender -G252-
For models with parking aid (PDC)
2 - Front right sender for park assist steering on right side of vehicle -G569-
For models with park assist steering
3 - Front right headlight -MX2-
4 - Light conductor for contour lighting in radiator grille, front right -L362-
5 - Adaptive cruise control unit -J428-
6 - Centre crash sensor for pedestrian protection -G693-
For models with pedestrian protection system
7 - Light conductor for contour lighting in radiator grille, front left -L363-
8 - Front left headlight -MX1-
9 - Front left sender for park assist steering on left side of vehicle -G568-
For models with park assist steering
10 - Left fog light -MX11-
11 - Front left parking aid sender -G255-
For models with parking aid (PDC)
12 - Treble horn -H2-
13 - Front passenger side crash sensor for pedestrian protection -G571-
For models with pedestrian protection system
14 - Front centre right parking aid sender -G253-
For models with parking aid (PDC)
15 - Ambient temperature sensor -G17-
16 - Front pressure hose sensor for pedestrian protection -G579-
For models with pedestrian protection system
17 - Front centre left parking aid sender -G254-
For models with parking aid (PDC)
18 - Bass horn -H7-
19 - Driver side crash sensor for pedestrian protection -G570-
For models with pedestrian protection system
20 - Right fog light -MX12-

Front VW Polo 6, from front left, part 1



A - 2-pin connector -T2ay-, black/2-pin connector -T2fa-, black
For models with 1.0l petrol engine, CHZB,CHZJ,CHZL
For models with 1.0l natural gas engine EcoFuel, DBYA
For models with 1.0l petrol engine, CHYB,CHYC
A - 2-pin connector -T2ay-, black/2-pin connector -T2ez-, black
For models with 1.0l petrol engine, DKJA, DKLA, DKRA, DKRF, DLAA, DLAC
For models with 1.0l MPI petrol engine, DFNA, DFNB, DSGB, DSGD
For models with 1.5l petrol engine, DADA, DPCA
A - 4-pin connector -T4ae-, black/4-pin connector -T4bo-, black
For vehicles with 1.0l petrol engine, CHZB, CHZJ, CHZL, DXTA
For models with 1.0l natural gas engine EcoFuel, DBYA
A - 4-pin connector -T4ae-, black/4-pin connector -T4bq-, black
For models with 1.0l petrol engine, DKJA, DKLA, DKRA, DKRF, DLAA, DLAC
For models with 1.0l petrol engine, CHYB,CHYC
For models with 1.0l MPI petrol engine, DFNA, DFNB, DSGB, DSGD
For models with 1.5l petrol engine, DADA, DPCA
A - 4-pin connector -T4bz-, black/4-pin connector -T4ca-, black
For models with 1.5l petrol engine, DPCA
A - 8-pin connector -T8h- , black/8-pin connector -T8ad-, black
For models with 1.6l diesel engine, DGTC, DGTD
A - 8-pin connector -T8g-, black/8-pin connector -T8ac-, black
For models with 2.0l petrol engine, CZPC, DKZC, DNND
B - 14-pin connector -T14l-, grey/14-pin connector -T14a-, grey
For models with 1.0l petrol engine, CHYB,CHYC
B - 14-pin connector -T14m-, grey/14-pin connector -T14d-, grey
For models with 1.0l natural gas engine EcoFuel, DBYA
For models with 1.0l petrol engine, DKJA, from September 2017, DKLA, DKRA, DKRF
For models with 1.0l MPI petrol engine, DFNA, DFNB, DSGB, DSGD
B - 14-pin connector -T14m-, grey/14-pin connector -T14f-, grey
For vehicles with 1.0l petrol engine, CHZB, CHZJ, CHZL, DXTA
B - 14-pin connector -T14m-, grey/14-pin connector -T14l-, grey
For models with 1.0l petrol engine, DLAA, DLAC
B - 14-pin connector -T14i-, grey/14-pin connector -T14l-, grey
For models with 1.0l petrol engine, DKJA, from July 2018
B - 14-pin connector -T14d-, grey/14-pin connector -T14q-, grey
For models with 1.5l petrol engine, DADA, DPCA
B - 14-pin connector -T14h-, grey/14-pin connector -T14n-, grey
For models with 1.6l diesel engine, DGTC, DGTD
B - 14-pin connector -T14c-, grey/14-pin connector -T14o-, grey
For models with 2.0l petrol engine, CZPC, DKZC, DNND
C - 10-pin connector -T10ar-, black/10-pin connector -T10as-, black
For models with 2.0l petrol engine, CZPC, DKZC
1 - Right washer jet heater element -Z21-
2 - Anti-theft alarm system horn -H8-
3 - Actuator for structure-borne sound -R214-
For models with 2.0l petrol engine
4 - Control unit for structure-borne sound -J869-
For models with 2.0l petrol engine
5 - Left washer jet heater element -Z20-
6 - Wiper motor control unit -J400-
7 - Battery -A-
Fitting location for models with battery at rear -> see fitting locations: rear part of vehicle
For models with battery in engine compartment
8 - Engine/motor control unit -J623-
9 - Windscreen washer fluid level sender -G33-
10 - Windscreen and rear window washer pump -V59-
11 - Radiator outlet coolant temperature sender -G83-
12 - Radiator fan thermal switch -F18-
For models with no air conditioning system
13 - Radiator fan -VX57-
14 - Pressure sender for refrigerant circuit -G805-
15 - ABS control unit -J104-


Front VW Polo 6, from front left, part 2



1 - Water separator sender -G63-
For models with 1.6l diesel engine
2 - Air mass measurement module -GX35-
For models with 1.6l diesel engine
For models with 2.0l petrol engine
3 - Control unit for NOx sender -GX30-
For models with 1.6l diesel engine
4 - Suppression filter -C10-
For models with 2.0l petrol engine
5 - Jump start connection -TV32-
For models with 2.0l petrol engine


Front from right VW Polo 6



1 - Brake fluid level warning contact -F34-
In RHD models accordingly on right-hand side of vehicle
2 - Clutch position sender -G476-
In RHD models accordingly on right-hand side of vehicle
3 - Trigger 1 for pedestrian protection -G598-
For models with pedestrian protection system
4 - Battery monitor control unit -J367-
Fitting location for models with battery at rear -> see fitting locations: rear part of vehicle
For models with battery in engine compartment
5 - Not installed
6 - Bonnet contact switch 2 -F329-
7 - Crash sensor for front airbag -G190-
8 - Bonnet contact switch -F266-
9 - Tank pressure sensor -G400-
10 - High-pressure valve for gas mode -N372-
11 - Coolant shortage indicator sender -G32-
12 - Trigger 2 for pedestrian protection -G599-
For models with pedestrian protection system
13 - Brake light switch -F-
In RHD models accordingly on right-hand side of vehicle
14 - Vacuum sender -G608-
In RHD models accordingly on right-hand side of vehicle

1.0l petrol engine, CHYB, CHYC, from front



1 - Activated charcoal filter solenoid valve 1 -N80-
2 - Injector, cylinder 1 -N30-
3 - Injector, cylinder 2 -N31-
4 - Injector, cylinder 3 -N32-
5 - Throttle valve module -GX3-
6 - Alternator with voltage regulator -CX1-
7 - Air conditioner compressor regulating valve -N280-
8 - Vacuum pump for brakes -V192-
9 - Oil pressure switch -F1-
10 - Intake manifold sender -GX9-


1.0l petrol engine, CHYB, CHYC from above



1 - Camshaft control valve 1 -N205-
2 - Ignition coil 1 with output stage -N70-
3 - Ignition coil 2 with output stage -N127-
4 - Ignition coil 3 with output stage -N291-
5 - Hall sender -G40-


1.0l petrol engine, CHYB, CHYC from rear



1 - Coolant temperature sender -G62-
2 - Lambda probe 1 before catalytic converter -GX10-
3 - Knock sensor 1 -G61-
4 - Lambda probe 1 after catalytic converter -GX7-
5 - Oil level and oil temperature sender -G266-
6 - Engine speed sender -G28-

1.0l petrol/natural gas engine, CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF, DXTA, from front



1 - Throttle valve module -GX3-
2 - Gas injection valve 1 -N366-
For models with natural gas engine
3 - Gas rail temperature and pressure sensor -GX21-
For models with natural gas engine
4 - Gas injection valve 2 -N367-
For models with natural gas engine
5 - Gas injection valve 3 -N368-
For models with natural gas engine
6 - Fuel pressure regulating valve -N276-
For engines with engine code CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF
6 - Fuel metering valve -N290-
For models with engine code DXTA
7 - Intake manifold sender -GX9-
8 - Injector, cylinder 3 -N32-
9 - Injector, cylinder 2 -N31-
10 - Injector, cylinder 1 -N30-
11 - Charge air cooling pump -V188-
12 - Air conditioner compressor regulating valve -N280-
13 - Alternator with voltage regulator -CX1-
14 - Vacuum pump for brakes -V192-
15 - Oil pressure sender -G10-
16 - Fuel pressure sender -G247-



1.0l petrol/natural gas engine, CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF, DXTA, from above



1 - Charge pressure sender -GX26-
2 - Pressure sensor for activated charcoal filter air flushing -GX44-
3 - Activated charcoal filter solenoid valve 1 -N80-
4 - Exhaust gas pressure sensor 1 -G450-
5 - Hall sender 3 -G300-
For models with engine code CHZB, CHZJ, CHZL, DBYA, DKJA, from September 2017, DKLA, DKRA, DKRF
5 - Hall sender 2 -G163-
For models with engine code DKJA from July 2018
5 - Exhaust camshaft position sender -G1003-
For models with engine code DXTA
6 - Hall sender -G40-
For engines with engine code CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF
6 - Inlet camshaft position sender -G1002-
For models with engine code DXTA
7 - Ignition coil 3 with output stage -N291-
8 - Ignition coil 2 with output stage -N127-
9 - Ignition coil 1 with output stage -N70-
10 - Camshaft control valve 1 -N205-
For engines with engine code CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF
10 - Inlet camshaft control valve 1 -N727-
For models with engine code DXTA
11 - Exhaust camshaft control valve 1 -N318-


1.0l petrol/natural gas engine, CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF, DXTA, from rear



1 - Charge pressure positioner -V465-
For engines with engine code CHZB, CHZJ, CHZL, DBYA, DKJA, DKLA, DKRA, DKRF
1 - Charge pressure control module -GX34-
For models with engine code DXTA
2 - Lambda probe 1 before catalytic converter -GX10-
3 - Lambda probe 1 after catalytic converter -GX7-
4 - Valve for oil pressure control -N428-
5 - Oil level and oil temperature sender -G266-
6 - Engine speed sender -G28-
7 - Knock sensor 1 -G61-
8 - Coolant temperature sender -G62-

1.0l petrol engine, DFNA, DFNB, DSGB, DSGD, from front



1 - Activated charcoal filter solenoid valve 2 -N115-
2 - Activated charcoal filter solenoid valve 1 -N80-
3 - Injector, cylinder 1 -N30-
4 - Injector, cylinder 2 -N31-
5 - Injector, cylinder 3 -N32-
6 - Engine temperature regulation module -GX33-
7 - Throttle valve module -GX3-
8 - Engine speed sender -G28-
9 - Air conditioner compressor regulating valve -N280-
10 - Alternator with voltage regulator -CX1-
11 - Knock sensor 1 -G61-
12 - Oil pressure sender -G10-
13 - Intake manifold sender -GX9-


1.0l petrol engine, DFNA, DFNB, DSGB, DSGD, from above



1 - Exhaust camshaft control valve 1 -N318-
2 - Ignition coil 1 with output stage -N70-
3 - Ignition coil 2 with output stage -N127-
4 - Ignition coil 3 with output stage -N291-
5 - Exhaust camshaft position sender -G1003-
6 - Inlet camshaft position sender -G1002-
7 - Fuel pressure sender for low pressure -G410-


1.0l petrol engine, DFNA, DFNB, DSGB, DSGD, from rear



1 - Lambda probe 1 before catalytic converter -GX10-
2 - Coolant temperature sender -G62-
3 - Inlet camshaft control valve 1 -N727-
4 - Valve for oil pressure control -N428-
5 - Oil level and oil temperature sender -G266-
6 - Lambda probe 1 after catalytic converter -GX7-
7 - Engine outlet coolant temperature sender -G82-

1.0l petrol engine, DLAA, DLAC, from front



1 - Fuel pressure sender -G247-
2 - Oil pressure sender -G10-
3 - Injector, cylinder 1 -N30-
4 - Injector, cylinder 2 -N31-
5 - Injector, cylinder 3 -N32-
6 - Throttle valve module -GX3-
7 - Engine temperature regulation module -GX33-
8 - Charge air cooling pump -V188-
9 - Air conditioner compressor regulating valve -N280-
10 - Magnetic clutch for supercharger -N421-
11 - Alternator with voltage regulator -CX1-
12 - Knock sensor 1 -G61-


1.0l petrol engine, DLAA, DLAC, from above



1 - Pressure sensor for activated charcoal filter air flushing -GX44-
2 - Exhaust camshaft control valve 1 -N318-
3 - Activated charcoal filter solenoid valve 1 -N80-
4 - Ignition coil 1 with output stage -N70-
5 - Exhaust gas pressure sensor 1 -G450-
6 - Exhaust camshaft position sender -G1003-
7 - Ignition coil 2 with output stage -N127-
8 - Ignition coil 3 with output stage -N291-
9 - Fuel metering valve -N290-
10 - Inlet camshaft position sender -G1002-
11 - Charge pressure sender -GX26-
12 - Intake manifold sender -GX9-
13 - Inlet camshaft control valve 1 -N727-


1.0l petrol engine, DLAA, DLAC, from rear



1 - Charge pressure control module -GX34-
2 - Lambda probe 1 before catalytic converter -GX10-
3 - Lambda probe 1 after catalytic converter -GX7-
4 - Piston cooling jet control valve -N522-
5 - Valve for oil pressure control -N428-
6 - Oil level and oil temperature sender -G266-
7 - Engine speed sender -G28-
8 - Engine outlet coolant temperature sender -G82-
9 - Coolant temperature sender -G62-

1.5l petrol engine, DADA, DPCA, from front



1 - Pressure sensor for activated charcoal filter air flushing -GX44-
2 - Activated charcoal filter solenoid valve 1 -N80-
3 - Engine temperature regulation module -GX33-
4 - Inlet camshaft position sender -G1002-
5 - Charge pressure sender -GX26-
6 - Knock sensor 1 -G61-
7 - Engine speed sender -G28-
8 - Charge air cooling pump -V188-
9 - Air conditioner compressor regulating valve -N280-
10 - Alternator with voltage regulator -CX1-
11 - Fuel pressure sender -G247-
12 - Vacuum pump for brakes -V192-
13 - Oil pressure sender -G10-
14 - Injector, cylinder 1 -N30-
15 - Injector, cylinder 2 -N31-
16 - Injector, cylinder 3 -N32-
17 - Injector, cylinder 4 -N33-


1.5l petrol engine, DADA, DPCA, from above



1 - Exhaust camshaft control valve 1 -N318-
2 - Exhaust camshaft position sender -G1003-
3 - Exhaust cam actuator for cylinder 2 -N587-
4 - Exhaust gas pressure sensor 1 -G450-
5 - Exhaust cam actuator for cylinder 3 -N595-
6 - Fuel metering valve -N290-
7 - Ignition coil 4 with output stage -N292-
8 - Ignition coil 3 with output stage -N291-
9 - Inlet cam actuator for cylinder 3 -N591-
10 - Inlet cam actuator for cylinder 2 -N583-
11 - Ignition coil 2 with output stage -N127-
12 - Ignition coil 1 with output stage -N70-


1.5l petrol engine, DADA, DPCA, from right



1 - Inlet camshaft control valve 1 -N727-
2 - Intake manifold sender -GX9-
3 - Throttle valve module -GX3-
4 - Valve for oil pressure control -N428-


1.5l petrol engine, DADA, DPCA, from rear



1 - Lambda probe 1 before catalytic converter -GX10-
2 - Lambda probe 1 after catalytic converter -GX7-
3 - Oil level and oil temperature sender -G266-
4 - Engine outlet coolant temperature sender -G82-
5 - Coolant temperature sender -G62-
6 - Charge pressure control module -GX34-

1.6l petrol engine, CWVB, from front



1 - Activated charcoal filter solenoid valve 1 -N80-
2 - Throttle valve module -GX3-
3 - Air conditioner compressor regulating valve -N280-
4 - Alternator with voltage regulator -CX1-
5 - Knock sensor 1 -G61-
6 - Oil pressure switch -F1-


1.6l petrol engine, CWVB, from above



1 - Camshaft control valve 1 -N205-
2 - Ignition coil 1 with output stage -N70-
3 - Ignition coil 2 with output stage -N127-
4 - Ignition coil 3 with output stage -N291-
5 - Ignition coil 4 with output stage -N292-
6 - Hall sender -G40-
7 - Injector, cylinder 4 -N33-
8 - Injector, cylinder 3 -N32-
9 - Injector, cylinder 2 -N31-
10 - Injector, cylinder 1 -N30-


1.6l petrol engine, CWVB, from left



1 - Intake manifold sender -GX9-
2 - Engine speed sender -G28-


1.6l petrol engine, CWVB, from rear



1 - Lambda probe 1 before catalytic converter -GX10-
2 - Coolant temperature sender -G62-

1.6l diesel engine, DGTC, DGTD, from front



1 - Fuel metering valve -N290-
2 - Hall sender -G40-
3 - Charge air temperature sender after charge air cooler -G811-
4 - Charge pressure sender -G31-
5 - Exhaust gas recirculation valve 1 -GX5-
6 - Oil pressure switch for reduced oil pressure -F378-
7 - Oil pressure switch -F1-
8 - Charge air cooling pump -V188-
9 - Air conditioner compressor regulating valve -N280-
10 - Valve for oil pressure control -N428-
11 - Alternator with voltage regulator -CX1-


1.6l diesel engine, DGTC, DGTD, from above



1 - Injector, cylinder 1 -N30-
2 - Pressure differential sender -G505-
3 - Injector, cylinder 2 -N31-
4 - Injector, cylinder 3 -N32-
5 - Injector, cylinder 4 -N33-
6 - Fuel pressure regulating valve -N276-
7 - Glow plug 4 -Q13-
8 - Glow plug 3 -QX3-
9 - Glow plug 2 -Q11-
10 - Glow plug 1 -Q10-
11 - Fuel temperature sender -G81-
12 - Coolant valve for cylinder head -N489-
13 - Fuel pressure sender -G247-


1.6l diesel engine, DGTC, DGTD, from left



1 - Intake air temperature sender -G42-
2 - Heater element for crankcase breather -N79-
3 - Coolant temperature sender -G62-
4 - Engine speed sender -G28-
5 - Throttle valve module -GX3-


1.6l diesel engine, DGTC, DGTD, from rear



1 - Position sender for charge pressure positioner -G581-
2 - Lambda probe 1 before catalytic converter -GX10-
3 - NOx sender -G295-
4 - Exhaust gas temperature sender 3 -G495-
5 - Injector for reducing agent -N474-
6 - Exhaust gas temperature sender 2 -G448-
7 - Exhaust gas temperature sender 1 -G235-
8 - Exhaust gas temperature sender 4 -G648-
9 - Auxiliary pump for heating -V488-
10 - Oil level and oil temperature sender -G266-
11 - Exhaust gas recirculation valve 2 -GX6-
12 - Charge pressure control solenoid valve -N75-

2.0l petrol engine, CZPC, DKZC, from front



A - 8-pin connector -T8b-, black/8-pin connector -T8aa-, black
B - 8-pin connector -T8ae-, black/8-pin connector -T8ab-, black
C - 14-pin connector -T14y-, black/14-pin connector -T14x-, black
1 - Injector 2, cylinder 1 -N532-
2 - Injector 2, cylinder 2 -N533-
3 - Injector 2, cylinder 3 -N534-
4 - Injector 2, cylinder 4 -N535-
5 - Hall sender -G40-
6 - Stage 3 oil pressure switch -F447-
7 - Engine speed sender -G28-
8 - Actuator for engine temperature regulation -N493-
9 - Air conditioner compressor regulating valve -N280-
10 - Throttle valve module -GX3-
11 - Alternator with voltage regulator -CX1-
12 - Fuel pressure sender -G247-
13 - Fuel pressure sender for low pressure -G410-


2.0l petrol engine, DNND, from front



A - 8-pin connector -T8ab-, black/8-pin connector -T8ah-, black
B - 14-pin connector -T14b-, black/14-pin connector -T14z-, black
1 - Alternator with voltage regulator -CX1-
2 - Intake manifold flap potentiometer -G336-
3 - Piston cooling jet control valve -N522-
4 - Throttle valve module -GX3-
5 - Hall sender -G40-
6 - Engine temperature regulation module -GX33-
7 - Stage 2 oil pressure switch -F446-
8 - Engine speed sender -G28-
9 - Coolant valve for gearbox -N488-
10 - Oil level and oil temperature sender -G266-
11 - Not installed
12 - Charge pressure sender -G31-
13 - Magnetic clutch for supercharger -N421-


2.0l petrol engine, CZPC, DKZC, from above



1 - Hall sender 3 -G300-
2 - Fuel pressure regulating valve -N276-
3 - Inlet cam actuator B for cylinder 3 -N593-
4 - Inlet cam actuator B for cylinder 4 -N601-
5 - Inlet cam actuator A for cylinder 4 -N600-
6 - Inlet cam actuator A for cylinder 3 -N592-
7 - Injector, cylinder 4 -N33-
8 - Intake manifold flap valve -N316-
9 - Intake manifold sender -GX9-
10 - Injector, cylinder 3 -N32-
11 - Knock sensor 1 -G61-
12 - Injector, cylinder 2 -N31-
13 - Injector, cylinder 1 -N30-
14 - Intake manifold flap potentiometer -G336-
15 - Inlet cam actuator B for cylinder 2 -N585-
16 - Inlet cam actuator A for cylinder 1 -N576-
17 - Inlet cam actuator B for cylinder 1 -N577-
18 - Inlet cam actuator A for cylinder 2 -N584-
19 - Activated charcoal filter solenoid valve 1 -N80-
20 - Ignition coil 1 with output stage -N70-
21 - Ignition coil 2 with output stage -N127-
22 - Ignition coil 3 with output stage -N291-
23 - Ignition coil 4 with output stage -N292-


2.0l petrol engine, DNND, from above



1 - Ignition coil 1 with output stage -N70-
2 - Activated charcoal filter solenoid valve 1 -N80-
3 - Ignition coil 2 with output stage -N127-
4 - Ignition coil 3 with output stage -N291-
5 - Ignition coil 4 with output stage -N292-
6 - Turbocharger air recirculation valve -N249-
7 - Hall sender 3 -G300-
8 - Fuel metering valve -N290-
9 - Actuator 6 for camshaft adjustment -F371-
10 - Actuator 8 for camshaft adjustment -F373-
11 - Actuator 7 for camshaft adjustment -F372-
12 - Injector, cylinder 4 -N33-
13 - Intake manifold flap valve -N316-
14 - Intake manifold sender -GX9-
15 - Injector, cylinder 3 -N32-
16 - Knock sensor 1 -G61-
17 - Injector, cylinder 2 -N31-
18 - Fuel pressure sender -G247-
19 - Injector, cylinder 1 -N30-
20 - Actuator 4 for camshaft adjustment -F369-
21 - Actuator 2 for camshaft adjustment -F367-
22 - Actuator 1 for camshaft adjustment -F366-
23 - Actuator 3 for camshaft adjustment -F368-
24 - Actuator 5 for camshaft adjustment -F370-


2.0l petrol engine, CZPC, DKZC, from left



1 - Turbocharger air recirculation valve -N249-
2 - Charge pressure positioner -V465-
3 - Auxiliary pump for heating -V488-
4 - Oil level and oil temperature sender -G266-
5 - Not installed
6 - Coolant temperature sender -G62-
7 - Not installed
8 - Coolant shut-off valve -N82-


2.0l petrol engine, CZPC, DKZC, DNND, from right



1 - Exhaust camshaft control valve 1 -N318-
2 - Camshaft control valve 1 -N205-
3 - Oil pressure switch -F22-
4 - Oil pressure switch for reduced oil pressure -F378-
5 - Piston cooling jet control valve -N522-
For models with engine code CZPC, DKZC
Fitting location for models with engine code DNND ⇒ Item 3
6 - Valve for oil pressure control -N428-


2.0l petrol engine, CZPC, DKZC, from rear



1 - Lambda probe 1 before catalytic converter -GX10-
2 - Pressure differential sender for particulate filter -G1037-
3 - Lambda probe 1 after catalytic converter -GX7-


2.0l petrol engine, DNND, from rear



1 - Pressure differential sender for particulate filter -G1037-
2 - Lambda probe 1 before catalytic converter -GX10-
3 - Not installed
4 - Lambda probe 1 after catalytic converter -GX7-
5 - Charge pressure control module -GX34-
6 - Coolant circulation pump -V50-
7 - Coolant temperature sender -G62-

Dual clutch gearbox, 0CW



1 - Starter -B-
2 - Mechatronic unit for dual clutch gearbox -J743-

Dual clutch gearbox, 0D9



1 - Coolant valve for gearbox -N488-
2 - Starter -B-
3 - Mechatronic unit for dual clutch gearbox -J743-

Dual clutch gearbox, 0GC



A - 5-pin connector -T5aj-, black/5-pin connector -T5ak-, black
1 - Starter -B-
2 - Mechatronic unit for dual clutch gearbox -J743-
3 - not assigned
4 - Auxiliary hydraulic pump 1 for gearbox oil -V475-

Manual gearbox



1 - Starter -B-
2 - Gearbox neutral position sender -G701-
3 - Reversing light switch -F4-

Front left of interior, LHD models VW Polo 6, sales type AW1
For left-hand drive models
For models with sales type AW1



A - 38-pin connector -T38e- , black
B - 3-pin connector -T3as-, yellow/3-pin connector -T3bf-, yellow
C - 2-pin connector -T2cq-, red/2-pin connector -T2eu-, red
D - 2-pin connector -T2cs-, black/2-pin connector -T2ev-, black
E - 28-pin connector -T28c-, grey
1 - Driver side curtain airbag igniter -N251-
2 - Front left treble loudspeaker -R20-
3 - Amplifier -R12-
4 - Front left seat belt -NX10-


Front left of interior, LHD models VW Polo 6, sales type AE1
For left-hand drive models
For models with sales type AE1



A - 38-pin connector -T38e- , black
B - 17-pin connector -T17a-, yellow/17-pin connector -T17c-, yellow
C - 28-pin connector -T28c-, grey
1 - Driver side curtain airbag igniter -N251-
2 - Front left treble loudspeaker -R20-
3 - Amplifier -R12-
4 - Driver seat belt tensioner igniter 1 -N153-
5 - Front left seat belt -NX10-

Left footwell, LHD models VW Polo 6
For left-hand drive models



1 - Light for left dashboard background lighting -L229-
2 - Headlight range control unit -J431-
3 - Front parking aid warning buzzer -H22-
4 - Light for centre dashboard background lighting -L231-
5 - Seat heating control unit -J882-
6 - Front left footwell light -K268-
7 - Not installed
8 - Accelerator pedal module -GX2-
9 - Data bus diagnostic interface -J533-
For models with separate data bus diagnostic interface
10 - Parking aid control unit -J446-
11 - Onboard supply control unit -J519-
12 - Diagnostic connection -U31-
13 - Headlight range control regulator -E102-
14 - Rotary light switch -EX1-

Front right of interior, LHD models VW Polo 6, sales type AW1
For left-hand drive models
For models with sales type AW1



A - 38-pin connector -T38f- , black
B - 28-pin connector -T28b- , black
C - 4-pin connector -T4aq-, black/4-pin connector -T4bl-, black
D - 2-pin connector -T2cr-, red/2-pin connector -T2fl-, red
E - 3-pin connector -T3ar-, yellow/3-pin connector -T3bj-, yellow
F - 2-pin connector -T2cb-, black/2-pin connector -T2ha-, black
For models with air conditioning system
1 - Front right seat belt -NX11-
2 - Front right footwell light -K269-
3 - Loudspeaker for emergency call module -R335-
4 - Interface for entry and start system -J965-
For models with entry and start authorisation
5 - Key operated switch to deactivate airbag on front passenger side -E224-
6 - Control unit 1 for information electronics -J794-
For models with Composition Media, Discover Media/Discover Pro (Standard/High)
Fitting location for models with Composition Touch, Composition Colour (Entry)
6 - CD player -R89-
According to equipment
7 - Light for right dashboard background lighting -L230-
8 - Airbag igniter 1 on front passenger side -N131-
9 - Right vent temperature sender -G151-
10 - Front right treble loudspeaker -R22-
11 - Front passenger side curtain airbag igniter -N252-


Front right of interior, LHD models VW Polo 6, sales type AE1
For left-hand drive models
For models with sales type AE1



A - 38-pin connector -T38f- , black
B - 28-pin connector -T28b- , black
C - 17-pin connector -T17b-, yellow/17-pin connector -T17d-, yellow
D - 2-pin connector -T2cb-, black/2-pin connector -T2ha-, black
For models with air conditioning system
1 - Front passenger seat belt tensioner igniter 1 -N154-
2 - Front right seat belt -NX11-
3 - Front right footwell light -K269-
4 - Loudspeaker for emergency call module -R335-
5 - Control unit 1 for information electronics -J794-
For models with Composition Media, Discover Media/Discover Pro (Standard/High)
Fitting location for models with Composition Touch, Composition Colour (Entry)
5 - CD player -R89-
According to equipment
6 - Interface for entry and start system -J965-
For models with entry and start authorisation
7 - Key operated switch to deactivate airbag on front passenger side -E224-
8 - Light for right dashboard background lighting -L230-
9 - Airbag igniter 1 on front passenger side -N131-
10 - Right vent temperature sender -G151-
11 - Front right treble loudspeaker -R22-
12 - Front passenger side curtain airbag igniter -N252-

Dash panel, LHD models VW Polo 6
For left-hand drive models



1 - Left vent temperature sender -G150-
2 - Dash panel insert -KX2-
3 - Emergency call module control unit and communication unit -J949-
4 - Sunlight penetration photosensor -G107-
5 - Warning lamp for airbag deactivated on front passenger side -K145-
6 - Hazard warning light switch -EX3-
7 - Display unit for front information display and operating unit control unit -J685-
7 - Control unit 1 for information electronics -J794-
For models with Composition Touch, Composition Colour (Entry)
Fitting location for models with Composition Media, Discover Media/Discover Pro (Standard/High), sales type AW1 ⇒ Item 6
Fitting location for models with Composition Media, Discover Media/Discover Pro (Standard/High), sales type AE1 ⇒ Item 5
8 - Heater and air conditioning controls -EX21

Steering wheel VW Polo 6



1 - Steering column electronics control unit -J527-
2 - Airbag igniter on driver side -N95-
3 - Tiptronic switch in steering wheel to shift up -E438-
4 - Multifunction buttons on right in steering wheel -E441-
5 - Horn plate -H-
6 - Tiptronic switch in steering wheel to shift down -E439-
7 - Multifunction steering wheel control unit -J453-
8 - Not installed


Steering column VW Polo 6



1 - Steering column electronics control unit -J527-
2 - Immobiliser reader coil -D2-
3 - Ignition key withdrawal lock solenoid -N376-
4 - Power steering control unit -J500-
5 - Control unit for electronic steering column lock -J764-
For models with “keyless access” entry and start authorisation
6 - Ignition/starter switch -D